PERFORMANCE OF DEEP WELL PNEUMATIC PUMP | ||
| Misr Journal of Agricultural Engineering | ||
| Article 45, Volume 27, Issue 4, October 2010, Pages 1736-1756 PDF (928.22 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/mjae.2010.105341 | ||
| Authors | ||
| Samir Tayel1; Zakaria Yonis1; Alaa-El-Din Elmesery2; Adel Hasan3 | ||
| 1Prof. emerit of Agric. Eng.; Faulty of Agric.; (Cairo) Al-Azhar Uni., Egypt. | ||
| 2Assoc. Prof. of Agric. Eng.; Faulty of Agric.; (Cairo) Al-Azhar Uni., Egypt. | ||
| 3Post graduate student of Agric. Eng.; Faulty of Agric.; (Cairo) Al-Azhar Uni., Egypt. | ||
| Abstract | ||
| The research focused on development of pumps called pneumatic. This type of pumps use compressed air to lift water. The pumping principle uses compressed air acting directly upon the surface of the liquid being pumped, maintaining an air/liquid interface. The main objectives of the present study were: Construct a simple model of pneumatic pump by available materials, evaluate some engineering parameters of pneumatic pump, draw and estimate the performance curve of pneumatic pump at lifting water (from 20 to 60m)and study of operation cost of pneumatic pump. The pneumatic pump could be double or single-acting but double-acting is better and it consists of the main unit and assistance unit The study parameters are:- Stroke length of pump prototype were of 10,20,30, 40,50,60,70,80,90,100cm. And water lift (pressure head)of 20, 30, 40, 50, 60 meters. At every opening position, some variables were measured as: Discharge rate, air pressure manometer, volt, ampere, full time and pulse time. The results can be summarized as:- The pump performance at stroke length of 80cm for double-acting at different heads had good result for efficiency at head 20m, discharge was 0.58 l/s, the consumed power for pump was 0.31 kW, the air consumption was 3.9 m3 N. air/m3water and efficiency for pump was 37.11%, while total efficiency was 14.65%, but at head 60m discharge was 0.2 l/s, the consumed power for pump was 0.28 kW, the air consumption was 7.1 m3 N. air/m3water and efficiency for pump was 42.55%, while total efficiency was 13.78%. The results show that total cost = 0.453 L.E/h and the total cost of lifting water at different pump lifts was 0.22 L.E/m3 at 20m lift by flow rate of 2.073m3/h and 0.63 L.E/m3 at 60m lift by flow rate of 0.719 m3/h. | ||
| References | ||
|
ASAE. 1997. Standards (44th Ed.),: 357-362. The American Society of Agricultural Engineers (ASAE). Miami. USA. C.f. Emam (2001).
Addison. H. (1948) Centrifugal and other rotodynamic pumps. Chpman&Hall LTD.: 157-158.
Cherkassky.V. M. (1985) Pumps fans compressors. Translated from the russian by B. A. Nikolaev. Mir Publishers . Moscow.: 21:25.
Hansen. V.E; W. I Orson; E.S Glen. (1980) Irrigation principles and practices. John Wiley & Sons. :279:280.
RMS. Pitbull Pumps
Thomas F. Scherer,(l993) Irrigation water pumps. Extension gricultural Engineer. North Dakota State University Agriculture http.7/www.ag.ndsu.edu/pubs/ageng/irrigate/ae 1057w.htm
Hasan, A, A (2007) A study on deep well pump. M. Sc. Th., Agric Eng., Dept., Fac., of Agric., Al-azhar univ. | ||
|
Statistics Article View: 741 PDF Download: 253 |
||
