ISOLATION AND CHARACTERIZATION OF RHAMNOLIPID (BIOSURFACTANT) FROM PETROLEUM CONTAMINATED SOIL | ||
| Assiut University Bulletin for Environmental Researches | ||
| Article 8, Volume 12.1, Issue 12.1, March 2009, Pages 95-107 PDF (912.29 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/auber.2009.149543 | ||
| Abstract | ||
| ABSTRACT: In the last decades, biosurfactants have attracted attention of many scientists because of their low toxicity, biodegradability and ecological acceptability. Nevertheless, their use is extremely limited due to the high cost when compared with chemical surfactants. In this study we have isolated bacteria from different environmental sources located in Sarris field (Zawia–Libya). The isolate was identified as Pseudomonas aeruginosa by comparing its 16S rDNA sequence with those available in The National Center for Biotechnology Information (NCBI) gene bank (accession number was AJ746 135). Using gel electrophoresis technique, the length of DNA was identified. The strain was selected for its ability to produce extra cellular products (biosurfactants) able to reduce surface tension and emulsify the kerosene. The production of rhamnolipid was carried out using a well-controlled one-liter laboratory-scale flask fermentor. In the same time, optimum concentration of substrate (glycerol) was investigated and phenol sulphuric acid test was conducted to measure the concentration of produced rhamnolipid. The identification tests such as specific growth rate (µ), protein measurement, emulsification activity and stability test were also studied. The results showed that the extracellular surface active agent produced by the indigenous strain P. aeruginosa was identified as Rhamnolipid, which is one of the most commonly used biosurfactants with the ability to reduce surface tension of water. The maximum concentration of rhamnolipid isolated using 1% glycerol which was 170mg/l. This biosurfactant had excellent emulsification index (E24) of 70% and stability of 67% comparable to or better than that from the conventional rhamnolipid which was 66% and 58% respectively. | ||
| References | ||
REFERENCES:1-Karanth NGK, Deo PG, Veenanadig NK (1999): Microbial production of biosurfactants and their importance. Curr Sci. 77:116–126.
2-Costa SGVAO, Nitschke M, Haddad R, Eberlin M, Contiero J (2006): Production of Pseudomonas aeruginosa LBI rhamnolipids following growth on Brazilian native oils. Process Biochem. 41:483–488
3-Mulligan CN., Catherine N., (2005): Environmental application for biosurfactants. Environ Pollut 133:183–198
4-Volkering F., Breure A.M., Rulkens W.H. (1998): Microbiological aspects of surfactant use for biological soil remediation, Biodegradation. 8:401–417.
5-Mulligan C.N., Yong R.N., Gibbs B.F. (2001): Surfactant-enhanced remediation of contaminated soil: a review, Eng. Geol. 60: 371–380.
6-Falatko D.M., Novak J.T.(1992): Effect of biologically produced surfactants on the mobility and biodegradation of petroleum hydrocarbons, Water Environ. Res. 64 (2) 163–169.
7-Banat I.M., Makkar R.S., Cameotra S.S., (2000): Potential commercial applications of microbial surfactants, Appl. Microbiol. Biotechnol. 53: 495–508.
8-Anna L.M.S., Sebastian G.V., Pereira JR N., Alves T.L.M., Menezes E.P., Freire D.M.G.(2001): Production of Biosurfactant from a New and Promising Strain of Pseudomonas aeruginosa PA1, Applied Biochemistry and Biotechnology, 92: 459-467.
9-Desai, J.D. and Banat, I.M., (1997): Microbial Production of surfactants and their commercial potential. Microbiology and molecular biology reviews, Mar. p. 47—64.
10-Wei Y.H., Chou J.L., Chang J.S. (2005): Rhamnolipid production by an indigenous isolate Pseudomonas aeruginosa J4 originating from petrochemical wastewater, Biochem. Eng. J. 27 (2) 146–154.
11-Dai Kitamoto, Hiroko Isoda, Tadaatsu Nakahara, (2002): Functions and Potential Applications of Glycolipid Biosurfactants from Energy-Saving Materials to Gene Delivery Carriers. Journal of Bioscience and Bioengineering, 94: 187-201.
12-Kitamoto, D. (2001): New findings on glycolipid biosurfactants ranging from biologically active compounds to energy-saving materials. Oleoscience, 1: 17–31
13-Soberón-Chávez, G., Lépine, F. and Déziel, (2005): E. Production of rhamnolipids by Pseudomonas aeruginosa. Appl. Microbiol. Biotechn., 68: 718-725.
14-Dembitsky, V.M. (2004): Astonishing diversity of natural surfactants: 1. Glycosides of fatty acids and alcohols. Lipids, 39: 933-953.
15-Van Bogaert, I.N.A., Saerens, K., De Muynck, C., Develter, D., Soetaert, W. and Vandamme, (2007): E.J. Microbial production and application of sophorolipids. Appl. Microbiol. Biotechn., 76: 23-34.
16-Arutchelvi, J.I., Bhaduri, S., Uppara, P.V. and Doble, M. (2008): Mannosylerythritol lipids: a review. J. Ind. Microbiol. Biotechnol., 35, 1559-1570.
17-Gautam K.K. and Tyagi V.K. (2005): Microbial Surfactants: A Review. Journal of Oleo Science 55 (4): 155-166.
18-Malin Hultberg, Karl-Johan Bergstrand, Sammar Khalil and Beatrix Alsanius. (2008): Characterization of biosurfactant-producing strains of fluorescent pseudomonads in a soilless cultivation system. Journal of Antonie van Leeuwenhoek. 94: 329-334.
19-Maier R. M., Soberon Chavez G. (2000): Pseudomonas aeruginosa rhamnolipids: biosynthesis and potential applications. J of Applied microbiology and biotechnology. 54:(5) 625-633.
20-Ochoa-Loza, F.J., J.F. Artiola, and R.M. Maier. (2001): Stability constants for the complexation of various metals with a rhamnolipid biosurfactant. Journal of Environmental Quality 30:479-485.
21-Neilson, J.W., Artiola J.F., and Maier R.M. (2003): Characterization of lead removal from contaminated soils by nontoxic soil-washing agents. Journal of Environmental Quality 32:899-908.
22-Stanghellini, M.E. and R.M. Maier (Miller). (1997): Biosurfactants: their identity and potential efficacy in the biological control of zoosporic plant pathogens. Plant Disease 81:4-12.
23-Liang-Ming Whang, Pao-Wen G. Liu, Chih-Chung Ma and Sheng-Shung Cheng. (2008): Application of rhamnolipid and surfactin for enhanced diesel biodegradation-Effects of pH and ammonium addition. Journal of Hazardous Materials. (Article in Press).
24-Marcia Nitschke, Siddhartha G. V. A. O. Costa, Renato Haddad, Lireny A. G. Gonçalves, Marcos N. Eberlin, Jonas Contiero. (2005): Oil Wastes as Unconventional Substrates for Rhamnolipid Biosurfactant Production by Pseudomonas aeruginosa LBI. Biotechnology Progress. 21(5): 1562 – 1566.
25-Marcia Nitschke, Siddhartha G. V. A. O. Costa, Jonas Contiero. (2008): Rhamnolipid Surfactants: An Update on the General Aspects of These Remarkable Biomolecules. Biotechnology Progress. 21 (6): 1593 – 1600.
26-Wouter H. Noordman† and Dick B. Janssen. (2002): Rhamnolipid Stimulates Uptake of Hydrophobic Compounds by Pseudomonas aeruginosa. 68(9): 4502–4508.
27-Anand S. Nayaka, M.H. Vijaykumara and T.B. Karegoudar. (2009): Characterization of biosurfactant produced by Pseudoxanthomonas sp. PNK-04 and its application in bioremediation. International Biodeterioration & Biodegradation. 63 (1): 73-79.
28-Kosaric, N., (2001): Biosurfactants for Soil Bioremediation, Food Technol. Biotechnol., 39:295-304.
29-David Hendricks Bergey, John G. Holt (1994): “Bergey's Manual of Determinative Bacteriology” Vol. 9, Lippincott Williams & Wilkins, pp. 3-17.
30-Andrew Macrae (2000): The Use of 16S RDNA Methods in Soil Microbial Ecology. Brazilian Journal of Microbiology, 31:77-82.
31-The National Center for Biotechnology Information (NCBI) (2008): BLAST finds regions of similarity between biological sequences. www.ncbi.nlm.nih. gov/BLAST.
32-Lowry, O. H., Rosenbrough N. J., Randall R. J. (1951): Protein Measurement with the Folin Phenol Reagent. J. Biol. Chem., 193: 265-275.
33-Santa Anna, L.M., Sebastian, G.V., Menezes, E.P., Alves, T.L.M., Santos, AS., Pereira Jr., N. and Freire, D.M.G., (2002). Production of biosurfactants from Pseudomonas aeruginosa Pal isolated in oil environments, Brazilian Journal of Chemical Engineering, 19:159-166.
34-David G. Cooper and Beena G. Goldenberg. (1987): Surface-Active Agents from Two Bacillus Species. Appl Environ Microbiol. 53(2): 224-229.
35-Dubois M., Gilles K. A., Hamilton J. K., Rebers P. A., Smith F., (1956): Colorimetric method for determination of sugars and related substances, Anal. Chem., 28: 350-356.
36-Anthony I Okoh, (2006): Biodegradation alternative in the cleanup of petroleum hydrocarbon pollutants. Biotechnology and Molecular Biology Review. 1 (2): 38-50.
37-Yeliz Asfçe, Macid Nurbasf, Yesfim Sag Açekel. (2008). Removal of zinc ions from a soil component Na-feldspar by a rhamnolipid biosurfactant. 223: 361–365. | ||
|
Statistics Article View: 131 PDF Download: 237 |
||
