Effect tensile behavior of spandex/polyester yarns on the stress–strain curves for woven fabrics | ||
| International Design Journal | ||
| Article 32, Volume 11, Issue 3 - Serial Number 40, May and June 2021, Pages 435-452 PDF (1.29 M) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/idj.2021.162531 | ||
| Authors | ||
| Haitham Abdel Daim Mahmoud Ahmed1; E. Rashwan2 | ||
| 1Lecturer-Spinning, Weaving, and knitting Department, Faculty of Applied Arts, Damietta University, Egypt, haitham.daim@gmail.com | ||
| 2Cotton Research Institute. Agric. Res. Cent., Giza, Egypt. | ||
| Abstract | ||
| The main goals of this study were to determine the effect of three yarn structural factors (yarn count, cross section and spandex ratio) and their interactions on tensile and breaking extension properties tensile behavior effect of spandex/polyester spun yarns respective on woven fabrics. Moreover, stress-strain curves were plotted and the yield points and breaking points and their corresponding properties (toughness, stiffness and Initial Young Modulus) were derived. The association between tensile and elongation parameters for spandex/polyester yarn and their woven fabrics was computed using simple correlation coefficient, results explained that all tensile and breaking extension properties significantly increased as the yarn count increased while the effect of cross section was weak or marginal. It is obvious that yield strain, yield stress, breaking extension, breaking tenacity decreased as a result of increasing the spandex content but the decrease percents (%) were generally weak. With respect to the 1st and 2nd order interaction effects, they were no significant for most tenacity and elongation properties of spandex/polyester spun yarns and their respective woven fabrics. The current study appeared that using spandex/polyester spun yarns with lowest spandex content gave the best tensile and breaking extension properties of spandex/polyester spun yarns and their respective woven fabrics. The correlation coefficients between tensile and elongation parameters for spandex/polyester yarn and their corresponding woven fabrics were positive and highly significant (except Initial Young's modulus) indicating that the tensile and breaking extension properties of the spandex/polyester yarns could be used as good indicators for the strength and elongation of fabrics manufactured by these spandex/polyester yarns. | ||
| Keywords | ||
| Spandex/Polyester Yarns; Stress-Strain Curves; Tensile And Breaking Extension Properties; Woven Fabrics | ||
| References | ||
|
1. Abdel Daim H.M.A. (2020). Effect of spinning factors on stress-strain curves in Egyptian cotton. International Design Journal, Volume 10, Issue 1:103-114. 2. AL-ansary, Mofeda A. (2011). Effect of spandex ratio on the properties of woven fabrics made of cotton / spandex spun yarns. Journal of American Science, 7(12): 63-67. 3. AL-ansary, Mofeda A. (2012). The influence of number of filaments on physical and mechanical characteristics of polyester woven fabrics. Life Science Journal, 9(3): 79-83. 4. Draper, N.R. and R. Smith (1981). Applied regression analysis. John Wiley and sons, Inc. New York. 704 pp. 5. Ghosh, A.; S.M. Ishtiaque and R.S. Rengasamy (2005). Stress–strain characteristics of different spun yarns as a function of strain rate and gauge length. Journal of the Textile Institute, 96 (2): 99–104. 6. Kamal, M.M.; Nafisa T. Ahmed and A.M. Ismail (1988). Stress-strain curve of single cotton yarns as affected by count and twist multiplier. Annals of Agricultural Science Moshtohor, 26 (2): 943-957. 7. Kaynak H. and O. Babaarslan (2015). Breaking strength and elongation properties of polyester woven fabrics on the basis of filament fineness. Journal of Engineered Fibers and Fabrics, Volume 10, Issue 4: 55-61. 8. Kaynak, H.K. and O.Babaarslan (2015). Breaking strength and elongation properties of polyester woven fabrics on the basis of filament fineness. Journal of Engineered Fibers and Fabrics, 10 (4): 55-61. 9. Mathur, k.; E. ElNashar; P. Hauser and A.M. Seyam (2008).Stretch potential of woven fabrics containing spandex. 5th International Conference of Textile Research Division NRC, Cairo, Egypt, Pages (1-19). 10.MINITAB INC. (2005). Minitab user’s guide, vers. 14. Minitab Inc, Harrisburg, Pennsylvania, USA. 11.Mourad, M.M.; M.H. Elshakankery and A.A. Almetwally (2012). Physical and stretch properties of woven cotton fabrics containing different rates of spandex. Journal of American Science, 8(4): 567-572. 12.Snedecor, G.W. and W.G. Cochron (1989). Statistical Methods. 8th Ed., Iowa State Univ. Press, Ames Iowa, USA. SPSS INC. (2004). SPSS 14. SPSS User’s guide. SPSS Inc, Chicago, IL, USA. | ||
|
Statistics Article View: 612 PDF Download: 1,417 |
||
