Synthesis of Agglomerated Hydroxyapatite Nanospheres with Performance as Anti-Viral Material | ||
| International Journal of Materials Technology and Innovation | ||
| Article 3, Volume 1, Issue 1, June 2021, Pages 1-17 PDF (976.09 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/ijmti.2021.181066 | ||
| Authors | ||
| E. A. Abdel-Aal* 1; R. Dawood2; E. M. Ewais3; W. A. Kandeel4; M. A. Shemis4; H. M. Abdel-Ghafar5 | ||
| 1Central Metallurgical Research and Development Institute | ||
| 2Biological Anthropology Department, Medical Division, National Research Centre, Giza, Egypt | ||
| 3Central Metallurgical Research and Development Institute (CMRDI), Helwan, Cairo, Egypt | ||
| 4Theodor Bilharz Research Institute, Giza, Egypt | ||
| 5Central Metallurgical Research and Development Institute (CMRDI), P.O. Box 87 Helwan, Cairo, Egypt | ||
| Abstract | ||
| Hydroxyapatite (HA) synthesized with the hydrothermal method was studied under various preparation conditions including variations of time, concentration of reactants, and concentration of surfactant, Aminotris (methylenephosphonic acid) [N(CH2PO3H2)3] (ATMP). Well elongated crystals with high degree of crystallinity were synthesized at 150 oC, initial pH adjusted to 9.0 ± 0.1 with no surfactant and a high concentration of reactants. Addition of the surfactant helped in increasing particle agglomeration and formation of clusters of micron sizes. HA crystal sizes were ranged from 1.4 µm to 5.1 µm whereas the crystallite sizes ranged from 26 nm to 38 nm. The antiviral screening of the hydroxyapatite was performed against Viruses that represent a threat to the public health community due to their minimal symptomatic control such as HAV, HSV-1, Adenovirus, and MERS. The antiviral activities of the synthesized compound were evaluated In vitro by viral infectivity Plaque assay. The obtained results revealed that the synthesized Hydroxyapatite - using 0.075 M CaHPO4 concentration for 25 hours hydrothermal time with 100 ppm surfactant - exhibited antiviral effect (52.9 %) against Virus HSV-1. HAV was slightly inhibited, whereas no antiviral activity was observed with respect to Adenovirus-5, and MERS. | ||
| Keywords | ||
| Hydroxyapatite; Hydrothermal synthesis; Aminotris (methylenephosphonic acid) surfactant; Experimental statistical design; Anti-Viral Plaque assay | ||
| References | ||
|
[1] K. Ioku, S. Yamauchi, H. Fujimori, S. Goto, and M. Yoshimura, Hydrothermal Preparation of Fibrous Apatite and Apatite Sheet, Solid State Ionics 151 (2002), 147-150. [2] F. Branda, A. Costantini, G. Luciani, F. Rosso, G. Peluso, and A. Barbarisi, Hydroxyapatite Coating of Polyelectrolite Hydrogels by Means of the Biomimetic Method, Materials Science & Engineering C 23(2003), 367-370. [3] A. Afshar, M. Ghorbani, N. Ehsani, M.R. Saeri, and C.C. Sorrell, Some Important Factors in the Wet Precipitation Process of Hydroxyapatite, Materials & Design, 24(2003), 197-202. [4] M. Niimi, T. Masuda, K. Kaihatsu, N. Kato, S. Nakamura, T. Nakaya, F. Arai, Virus Purification and Enrichment by Hydroxyapatite Chromatography on a Chip, Sensors and Actuators B: Chemical 201 (2004), 185-190. [5] E.A. Abdel-Aal, D Dietrich, S Steinhäuser, T Lampke, Strontium-substituted Hydroxyapatite Coatings on Titanium by Electrodeposition Technique, Journal for Electrochemistry and Plating Technology 3 (2011), 29-40. [6] R. Ramachandra Rao, H.N. Roopa, T.S. Kannan, Solid State synthesis and thermal stability of HAp and Hap-β-TCP composite ceramic powders, Journal of Materials Science-Materials in Medicine 8 (1997), 511–518. [7] P. Wang, C. Li, H. Gong, X. Jiang, H. Wang, K. Li; Effects of Synthesis Conditions on the Morphology of Hydroxyapatite Nanoparticles Produced by Wet Chemical Process, Powder Technology 203, 2 (2010), 315-321, DOI:10.1016/j.powtec.2010.05.023 [8] E.A. Abdel-Aal, D. El-Sayed, M. Shoeib, A.T. Kandil, Enhancing Coating of Brushite/hydroxyapatite Layer on Titanium Alloy Implant Surface with Additives, Applied Surface Science, Part B, 285 (2013), 136-143. [9] E.I. Dorozhkina, S.V. Dorozhkin, Application of the Turbidity Measurements to Study In Situ Crystallization of Calcium Phosphates, Colloids and Surfaces 203 (2002), 237–244. [10] G. Bezzi, G. Celotti, E. Landi, T.M.G. La Torretta, I. Sopyan, A. Tampieri, A novel Sol–gel Technique for Hydroxyapatite Preparation, Materials Chemistry and Physics 78 (2003), 816–824. [11] W. Weng, G. Han, P. Du, G. Shen, The effect of Citric Acid Addition on the Formation of Sol–gel Derived Hydroxyapatite, Materials Chemistry and Physics 74 (2002), 92–97. [12] K. Yamashita, T. Arashi, K. Kitagaki, S. Yamada, T. Umegaki, Preparation of Apatite Thin Films Through Sputtering From Calcium Phosphate Glasses, Journal of American Ceramic Society 77, 9 (1994), p. 2401–2407. [13] C.C. Silva, A.G. Pinheiro, M.A.R. Miranda, J.C. Go´ es, A.S.B. Sombra, Structural Properties of Hydroxyapatite Obtained by Mechanosynthesis, Solid State Sciences 5 (2003), 553–558. [14] S. Nakamura, T. Isobe, M. Senna, Hydroxyapatite Nano Sol Prepared via a Mechanochemical Route, Journal of Nanoparticle Research 3 (2001), 57–61. [15] E.A. Abdel-Aal, A.A. El-Midany,and H. El-Shall, Mechanochemical-Hydrothermal Preparation of Nano-crystallite Hydroxyapatite Using Statistical Design, Materials Chemistry and Physics 112 (2008), 202-207. [16] J. Liu, X. Ye, H. Wang, M. Zhu, B. Wang, and H. Yan, The Influence of pH and Temperature on the Morphology of Hydroxyapatite Synthesized by Hydrothermal Method, Ceramics International, 29, 6 (2003), 629-633. [17] G.K. Lim, J.Wang, S.C. Ng, C.H. Chew, L.M. Gan, Processing of Hydroxyapatite via micro emulsion and Emulsion Routes, Biomaterials, 18 (1997). 1433–1439. [18] X. Xiao, R. Liu, F. Liu, X. Zheng, D. Zhu; Effect of Poly(sodium 4-styrene-sulfonate) on the Crystal Growth of Hydroxyapatite Prepared by Hydrothermal Method, Materials Chemistry and Physics, 120 (2010), 603–607. [19] H. Zhang, B. W. Darvell; Synthesis and Characterization of Hydroxyapatite Whiskers by Hydrothermal Homogeneous Precipitation using Acetamide, Acta Biomaterialia, 6 (2010), 3216–3222. [20] H. El-Shall, M.M. Rashad, and E.A. Abdel-Aal, Effect of Phosphonate Additive on Crystallization of Gypsum in Phosphoric and Sulfuric Acid Medium, Crystal Research and Technology, 37 (2002), 1264-1273. [21] M.M. Rashad, M.H.H. Mahmoud, I.A. Ibrahim and E. A. Abdel-Aal, Effect of Citric Acid and 1,2- Dihydroxybenzene 3,5-disulfonic Acid on Crystallization of Calcium Sulfate Dihydrate Under Simulated Conditions of Phosphoric Acid Production, Crystal Research and Technology 40, 8 (2005), 741-747. [22] E. A. Abdel-Aal, H. M. Abdel-Ghafar, and M. B. El Anadouli; New Findings about Nucleation and Crystal Growth of Reverse Osmosis Desalination Scales with and without Inhibitor, Crystal Growth & Design 15, 10 (2015), 5133-5137. [23] H. El-Shall, M. M. Rashad, and E. A. Abdel-Aal; Effect of Cetyl Pyridinium Additive on Crystallization of Gypsum in Phosphoric and Sulfuric Acids Medium, Crystal Research and Technology 40, 9 (2005), 860-866. [24] H. El-Shall, E. A. Abdel-Aal and B. Moudgil, Cost-Effective Reagents as Defoamers and Crystal Modifiers to Enhance the Filtration of Phosphogypsum, Publication No. 01-141-162, Florida Industrial and Phosphate Research Institute (FIPR) Project No. 96-01-141, Florida University, USA, (1999),1-63, https://fipr.floridapoly.edu/ [25] H. El-Shall, E. A. Abdel-Aal and B. Moudgil, Effect of Surfactants on Phosphogypsum Crystallization and Filtration during Wet-Process Phosphoric Acid Production, Separation Science and Technology Journal, 35, 3 (2000), 395-410. [26] E.A. Abdel-Aal, M.H.H. Mahmoud, H. El-Shall, A.K. Ismail, Increasing the filtration rate of phospho-gypsum using surfactant, Hydrometallurgy, 85 (2007), 53-58. [27] L. Yan, Y. Li, Z. X. Deng, J. Zhuang, and X. Sun, Surfactant-Assisted Hydrothermal Synthesis of Hydroxyapatite Nanorods, International Journal of Inorganic Materials, 3 (2001), 633-637. [28] P. Vijayan, C. Raghu, G. Ashok, S.A. Dhanaraj, B. Suresh, Antiviral Activity of Medicinal Plants of Nilgiris, Indian J. Med. Res., 120 (2004), 24–29. [29] W. Randazzo, J. Piqueras, J. Rodrıguez-Diaz, R. Aznar and G. Sanchez, Improving Efficiency of Viability-qPCR for Selective Detection of Infectious HAV in Food and Water Samples, Journal of Applied Microbiology (2017), DOI 10.1111/jam.13519. [30] R.M. Pinto, J.M. Diez, and A. Bosch, Use of the Colonic Carcinoma Cell Line CaCo-2 for In Vivo Amplification and Detection of Enteric Viruses. J Med Virol 44 (1994), 310–315. [31] T. Mosman, Rapid Colorimetric Assay for Cellular Growth and Survival: Application to Proliferation and Cytotoxicity Assays. J. Immunol. Methods, 65 (1983), 55–63. [32] F. G. Hayden, K. M. Cote, R. G. Douglas Jr., Plaque Inhibition Assay for Drug Susceptibility Testing of Influenza Viruses, Antimicrobial Agents and Chemotherapy, 17, 6 (1980), 865-870, https//aac.asm.org [33] T.N. Kaul, E. Jr Middleton, and P.L. Ogra, Antiviral Effect of Flavonoids on Human Viruses. J. Med. Virol., 15 (1985), 71-79, [34] Hongquan Zhang, Youfa Wang, Yuhua Yan, and Shipu Li; Precipitation of Biocompatible Hydroxyapatite Whiskers from Moderately Acid Solution, Ceramics International, 29 (2003), 413-418. [35] E.A. Abdel-Aal, D. Dietrich, S. Steinhauser, B. Wielage; Electrocrystallization of Calcium Phosphate Coatings on Titanium Substrate at Different Current Densities, Surface & Coating Technology, 202 (2008), 5895-5900. [36] E.A. Abdel-Aal; Inserting of Strontium during Coating of Hydroxyapatite Compound on Titanium Substrate, International Journal of Nanoparticles, No. 1, 4 (2011), 77-92. [37] E.A. Abdel-Aal; Electrodeposition of Calcium Phosphate Coatings on Titanium Alloy Implant at Different Ca/P Ratios and Different Times, International Journal of Nano and Biomaterials, No. 2, 3 (2010), 187-202. [38] Q. Luo, J.D. Andrade, Cooperative Adsorption of Proteins onto Hydroxyapatite, Journal of Colloid and Interface Science, 200, 1(1998), 104-113. | ||
|
Statistics Article View: 465 PDF Download: 547 |
||
