Modified closed flat-plate photobioreactor for optimizing CO2 bio-fixation by the cyanobacterium Synechococcus elongatus | ||
| Egyptian Journal of Phycology | ||
| Article 1, Volume 23, Issue 1, 2022, Pages 89-113 PDF (965.69 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/egyjs.2022.148719.1015 | ||
| Authors | ||
| Osama Abd El-Aziz Swilam1; Ehab Fathy El-Belely2; Ahmed Darwish El-Gamal* 3 | ||
| 1Botany and Microbiology Department, Faculty of Science, Al-Azhar Universitty, Cairo, Egypt. | ||
| 2Botany and Microbiology Department, Faculty of Science, Al-Azhar University, Cairo, Egypt. | ||
| 3Botany and Microbiology Deptment, Faculty of Science, Al-Azhar University, Cairo (Boys) | ||
| Abstract | ||
| Global warming due to carbon dioxide (CO2) emissions is one of the most important environmental problems in the current century, therefore, there is an urgent need to search for effective eco-friendly strategies to reduce its risks. Biomass of autotrophic microorganisms has been used to reduce carbon dioxide emissions and to produce useful and economically valuable biomass. In the current study, a new strategy was used to improve the CO2 bio-fixation ability of the cyanobacterium S. elongatus, by modifying the design of the closed flat plate photobioreactor by adding mutually inverted U-shaped baffles to increase the efficiency of CO2 retention in the aqueous medium, thus increasing gas availability and utilization during photosynthesis. The results of the saturation and stability experiments indicated that optimal saturation occurred after 60–80 minutes and that the gas stability was for about 2 hours. The results of the bio-fixation experiment showed that the presence of fourteen baffles significantly increased the contact time between the trapped carbon dioxide and the culture medium of S. elongatus, in addition to preventing the rapid release of carbon dioxide from the aqueous medium, thus increasing the availability of carbon dioxide, which led to increasing the biomass productivity of S. elongatus. | ||
| Keywords | ||
| Biomass; Carbon dioxide emissions; Global warming; Modified flat-plate photobioreactor; Synechococcus elongatus | ||
| References | ||
|
Allen, M. M. (1968). Simple conditions for growth of unicellular blue‐green algae on plates 1, 2. Journal of phycology, 4(1): 1-4.
Allen, M. M. and Stanier, R. Y. (1968). Growth and division of some unicellular blue-green algae. Microbiology, 51(2): 199-202.
Cañedo, J. C. G., and Lizárraga, G. L. L. (2016). Considerations for Photobioreactor Design and Operation for Mass Cultivation of Microalgae, in N. Thajuddin, D. Dhanasekaran (eds.), Algae - Organisms for Imminent Biotechnology, IntechOpen, London. 10.5772/63069.
Cheng, J., Huang, Y., Feng, J., Sun, J., Zhou, J., and Cen, K. (2013). Mutate Chlorella sp. by nuclear irradiation to fix high concentrations of CO2. Bioresource technology, 136: 496-501.
Degen, J., Uebele, A., Retze, A., Schmid-Staiger, U., and Trösch, W. (2001). A novel airlift photobioreactor with baffles for improved light utilization through the flashing light effect. Journal of biotechnology, 92(2): 89-94.
Gao, C., Zhai, Y., Ding, Y., and Wu, Q. (2010). Application of sweet sorghum for biodiesel production by heterotrophic microalga Chlorella protothecoides. Applied Energy, 87(3): 756-761.
Guo, W., Cheng, J., Song, Y., Kumar, S., Ali, K. A., Wang, Y., Li, X. and Yang, W. (2020). Improving flashing light frequency and CO2 fixation rate with vortex movement of algal cells in raceway pond with conic baffles. Chemical Engineering Science, 216, 115536.
Hofmann, D. J., Butler, J. H., Dlugokencky, E. J., Elkins, J. W., Masarie, K., Montzka, S. A., and Tans, P. (2006). The role of carbon dioxide in climate forcing from 1979 to 2004: introduction of the Annual Greenhouse Gas Index. Tellus B: Chemical and Physical Meteorology, 58(5): 614-619.
Huang, Q., Jiang, F., Wang, L., and Yang, C. (2017). Design of photobioreactors for mass cultivation of photosynthetic organisms. Engineering, 3(3): 318-329.
Kumar, K., Dasgupta, C. N., Nayak, B., Lindblad, P., and Das, D. (2011). Development of suitable photobioreactors for CO2 sequestration addressing global warming using green algae and cyanobacteria. Bioresource technology, 102(8): 4945-4953.
Lee, Y. S., and Han, G. B. (2016). Complete reduction of highly concentrated contaminants in piggery waste by a novel process scheme with an algal-bacterial symbiotic photobioreactor. Journal of environmental management, 177: 202-212.
Mirón, A. S., Gomez, A. C., Camacho, F. G., Grima, E. M., and Chisti, Y. (1999). Comparative evaluation of compact photobioreactors for large-scale monoculture of microalgae. Journal of Biotechnology, 70: 249-270.
Mortezaeikia, V., Yegani, R., and Tavakoli, O. (2016). Membrane-sparger vs. membrane contactor as a photobioreactors for carbon dioxide biofixation of Synechococcus elongatus in batch and semi-continuous mode. Journal of CO2 Utilization, 16: 23-31.
Phukan, M. M., Chutia, R. S., Konwar, B. K., and Kataki, R. (2011). Microalgae Chlorella as a potential bio-energy feedstock. Applied Energy, 88(10): 3307-3312.
Raeesossadati, M. J., Ahmadzadeh, H., McHenry, M. P., and Moheimani, N. R. (2014). CO2 bioremediation by microalgae in photobioreactors: impacts of biomass and CO2 concentrations, light, and temperature. Algal Research, 6: 78-85.
Rippka, R., Deruelles, J., Waterbury, J. B., Herdman, M., and Stanier, R. Y. (1979). Generic assignments, strain histories and properties of pure cultures of cyanobacteria. Microbiology, 111(1): 1-61.
Sierra, E., Acién, F. G., Fernández, J. M., García, J. L., González, C., and Molina, E. (2008). Characterization of a flat plate photobioreactor for the production of microalgae. Chemical Engineering Journal, 138(1-3): 136-147.
Singh, R. N., and Sharma, S. (2012). Development of suitable photobioreactor for algae production–A review. Renewable and Sustainable Energy Reviews, 16(4): 2347-2353.
Soman, A. and Shastri, Y. (2015). Optimization of novel photobioreactor design using computational fluid dynamics. Applied energy, 140: 246-255.
APHA (2017). Standard Methods for the Examination of Water and Wastewater, 23rd edition, Baird R.B., Eaton A.D., Rice E.W. (eds.) American Public Health Association (APHA), American Water Works Association (AWWA), and the Water Environment Federation (WEF): Washington, DC.
Vo, H. N. P., Ngo, H. H., Guo, W., Nguyen, T. M. H., Liu, Y., Liu, Y., and Chang, S. W. (2019). A critical review on designs and applications of microalgae-based photobioreactors for pollutants treatment. Science of the Total Environment, 651: 1549-1568.
Wang, L. L., Tao, Y., and Mao, X. Z. (2014). A novel flat plate algal bioreactor with horizontal baffles: structural optimization and cultivation performance. Bioresource technology, 164: 20-27.
Wang, L., and You, X. (2013). Light-gradient Mixing Performance Improvement of the Flat Plate Photobioreactor with Waved Baffles. Chemical and Biochemical Engineering Quarterly, 27(2): 211-218.
Xu, L., Weathers, P. J., Xiong, X. R., and Liu, C. Z. (2009). Microalgal bioreactors: challenges and opportunities. Engineering in Life Sciences, 9(3): 178-189.
Zhao, B., Su, Y., Tao, W., Li, L., and Peng, Y. (2012). Post-combustion CO2 capture by aqueous ammonia: A state-of-the-art review. International Journal of Greenhouse Gas Control, 9: 355-371. | ||
|
Statistics Article View: 237 PDF Download: 484 |
||
