MOUSSA, A. (2018). NANO TREATMENT OF DECAYED CEMENT-LIME MORTARS FROM THE EDFENA ROYAL PALACE (ROSETTA, EGYPT). test, 5(5), 230-251. doi: 10.21608/shedet.005.16
Abubakr MOUSSA. "NANO TREATMENT OF DECAYED CEMENT-LIME MORTARS FROM THE EDFENA ROYAL PALACE (ROSETTA, EGYPT)". test, 5, 5, 2018, 230-251. doi: 10.21608/shedet.005.16
MOUSSA, A. (2018). 'NANO TREATMENT OF DECAYED CEMENT-LIME MORTARS FROM THE EDFENA ROYAL PALACE (ROSETTA, EGYPT)', test, 5(5), pp. 230-251. doi: 10.21608/shedet.005.16
MOUSSA, A. NANO TREATMENT OF DECAYED CEMENT-LIME MORTARS FROM THE EDFENA ROYAL PALACE (ROSETTA, EGYPT). test, 2018; 5(5): 230-251. doi: 10.21608/shedet.005.16

NANO TREATMENT OF DECAYED CEMENT-LIME MORTARS FROM THE EDFENA ROYAL PALACE (ROSETTA, EGYPT)

Shedet
Article 16, Volume 5, Issue 5, 2018, Pages 230-251    PDF (1.57 M)
Document Type: review papers
DOI: 10.21608/shedet.005.16
Author
Abubakr MOUSSA
Department of Conservation, Faculty of Archaeology, Cairo University, Egypt
Abstract
This article focuses on the identification of the used building materials and their most common degradation factors at the royal palace of king Farouk at Edfena, Rosetta, Egypt; and then assessing the most appropriate nano-consolidants for the decayed lime-based mortars at the palace, to achieve the target of this study; building materials were studied by means of XRD, FTIR spectroscopy and light optical microscope; in order to find out if there are any chemical decomposition or any physical failure. Halite salt was detected in the building limestone; mortars’ composition varies between lime and white Portland cement, while the plaster in the palace walls is a mixture of white Portland cement and lime. Plaster in the marina is a mixture of lime, white Portland cement and anhydrite. Pigment material in the green terrazzo is a mix of malachite and greenalite; portlandite abreast with brucite were found in the plaster and mortar mixtures in addition to clay minerals. Nanolime, nanotitanium, nanokaolin, nanosilica and multi-walled carbon nanotubes were used as consolidants, experimental study made it clear that nanotitanium and MWCNTs are the most appropriate consolidants in the current case study.
Keywords
Royal Palace; XRD analysis; IR spectroscopy; Building materials; Deterioration factors; nanolime; nanotitanium; nanokaolin; nanosilica; MWCNTs
References
  1. Abouseif (Doris Bahrins); Islamic Architecture in Cairo: An Introduction, American University Press, Cairo, 1989.
  2. Aggarwal (Paratibha), Singh (Rahul), Aggarwal (Yogesh), “Use of Nano-Silica in Cement Based Materials – A Review”, Civil & Environmental Engineering 2 (2015), pp. 1-11.
  3. Allhoff (Fritz), Lin (Patrick), Moore (Daniel), what is Nanotechnology and why does it Matter? from Science to Ethics, Blackwell Publishing, John Wiley & Sons Ltd, London, 2010.
  4. Alves (C.A.S.), Braga (S.M.A.), Trancoso (A.), “Characterization of Saline Pollution Affecting the Angra do Heroismo Cathedral, a Trachytic Monument of Terceira Island (Azores – Portugal)”, Ninth Annual V. M. Goldschmidt Conference, Portugal, 2005, pp. 1-10.
  5. Anjana (R), George (K.E), “Reinforcing Effect of Nano Kaolin Clay on PP/HDPE Blends”, International Journal of Engineering Research and Applications (IJERA) 2 (4), 2012, pp.868-872.
  6. Aston (Barbara), Harrel (James), Shaw (Ian), “Stone”, in Ancient Egyptian Materials and Technology, (Nicholson, P.T., and Shaw, I., Eds.,), Cambridge University Press, 1st ed., London, UK, 2001.
  7. Ayad (Achraf), Said (Aly), “Using Colloidal Nano Silica to Enhance the Performance of Cementitious Mortars”, Open Journal of Civil Engineering 8 (2018), pp. 82-90.
  8. Baglioni (Piero), Vargas (Ramón), Chelazzi (David), Gonzàlez (Marinés), Desprat (Alice) Giorgi (Rodorico), “The Maya Site of Calakmul: In Situ Preservation of Wall Paintings and Limestone Using Nanotechnology”, Studies in Conservation 51 (2), 2006, pp. 162-169.
  9. Bagnara (Joseph), Construction and Restoration of Terrazzo Floors, International Specialized Skills Institute, Australia, 2009.
  10. Bartz (Wojciech), Martusewicz (Jacek), “Terrazzo Floor from the Jewish Historical Institute in Warsaw – Mineralogical Characterization, Conservation and Impact of Fire”, Geoscience Records 1 (4), 2017, pp. 1-13.
  11. Bell (Jonathan), Böke (Hasan), “Comparing the Old and New: Traditional Building Materials and the Uch Monument Complex, Pakistan”, Conservation and Management of Archaeological Sites 12 (2), 2010, pp. 107–123.
  12. Bianchi (Quercia), Application of Nano-Silica in Concrete, PhD Thesis, Eindhoven University of Technology, the Netherlands, 2014.
  13. Borsoi (Giovanni), Nanostructured Lime-Based Materials for the Conservation of Calcareous Substrates, Faculty of Architecture and the Built Environment, Delft University of Technology, Netherlands 2017; ISSN 2212-3202.
  14. Borsoi (Giovanni), Lubelli (Barbara), van Hees (Rob), Veiga (Rosario), Silva (Antonio), “Optimization of Nanolime Solvent for the Consolidation of Coarse Porous Limestone”, Applied Physics A, Materials Science and Processing, Springer, 2016, pp. 1-10.
  15. Burgoyne (Michael), Mamluk Jerusalem: An Architectural Study, Published on behalf of the British School of Architecture in Jerusalem, by the World of Islamic Festival Trust, 1987, pp. 53- 54.
  16. Charola (A.E.), Puhringer (J.), Steiger (M.), “Gypsum: a Review of its Role in the Deterioration of Building Materials”, Journal of Environmental Geology 52 (2007), pp. 339-352.
  17. Cortese (Dalia), “The Nile: Its role in the Fortunes and Misfortunes of the Fatimid Dynasty During its Rule of Egypt (969-1171)”, History Compass 13 (1), 2015, pp. 20-29.
  18. Christensen (M.C.), Analysis of Mineral Salts from Monuments by Infra-Red Spectroscopy, The Royal Danish Academy of Fine Arts, School of Conservation, Copenhagen, Denmark 1995.
  19. Creswell, K.A.C., The Muslim Architecture of Egypt, Part II, Ayyubids and Early Bahrite Mamluk, 1959, pp. 135-138.
  20. Dadian (Hossein Sarhaddi), Ramli (Zuliskandar), Abdul Rahman (Nik Hassan Shuhaimi Nik), Mehrafarin (Reza), “X-Ray Diffraction and X-Ray Fluorescence Analysis of Pottery Shards From New Archaeological Survey in South Region Of Sistan, Iran”, Mediterranean Archaeology and Archaeometry 15 (3), 2015, pp. 45-56.
  21. Darweesh (H.H.M.), Awad (H.M.), Tawfik (A.), “Red bricks from Dakhla Formation Clay-Tushka Area- Incorporated with Some Industrial Waste by-Products”, Journal of Industrial Ceramic 31 (3), 2011, pp. 201-207.
  22. Dayal (A.M.), Varma (A.K.), “Exploration Technique”, in Shale Gas: Exploration and Environmental and Economic Impacts, ScienceDirect, 2017, pp. 65-93.
  23. Deniz (Aydemir), Gulsen  (Uzun), Havva  (Gumuş), Sonnur  (Yildiz), Sultan  (Gumuş), Timucin (Bardak) , Gokhan  (Gunduz), “Nanocomposites of Polypropylene/Nano Titanium Dioxide: Effect of Loading Rates of Nano Titanium Dioxide”, Materials Science (Medžiagotyra) 22 (3), 2016, pp. 364-369.
  24. Derrick (M.R.), Stulik (D.), Landry (J.M.), Infrared Spectroscopy in Conservation Science, The Getty Conservation Institute, Los Angeles, 1999.
  25. Doehne (E.), Selwitz (C.), Carson (D.), de Tagle (A.), “Damage to Monuments from the Crystallization of Mirabilite, Thenardite and Halite: Mechanisms, Environment, and Preventive Possilbilities”, Eleventh Annual V. M. Goldschmidt Conference, U.S.A, 2001, pp. 37-46.
  26. Fadzil (M.A.), Nurhasri (M.S.), Norliyati (M.A.), Hamidah (M.S.), Ibrahim (M.H.), Assrul (R. Z.), “Characterization of Kaolin as Nano Material for High Quality Construction”, MATEC Web of Conferences 103 (2017), pp. 1-9.
  27. Fernández (J.M), Alvarez (J.I), “Influence of Nanosilica and a Polycarboxylate Ether Superplasticizer on the Performance of Lime Mortars”, Cement and Concrete Research 43 (2013), pp. 12-24.
  28. Giorgi (Rodorico), Ambrosi (Moira), Toccafondi (Nicola), Baglioni (Piero), “Nanoparticles for Cultural Heritage Conservation: Calcium and Barium Hydroxide Nanoparticles for Wall Painting Consolidation”, Chemistry a European Journal 16 (2010), pp. 74-82.
  29. Gonçalves (Teresa Diaz), Pel (Leo), Rodrigues (Jose´ Delgado), “Drying of Salt-Contaminated Masonry: MRI Laboratory Monitoring”, Journal of Environmental Geology 52 (2007), pp. 293-302.
  30. Gryffroy (Jasper), Nanolime Consolidation of Porous Limestones: Influence on the Pore Network, Durability and Weathering Behavior, Master Thesis, Ghent University, Belgium, 2017.
  31. Harrell (J.A.), Storemyr (P.), “Ancient Egyptian Quarries: An Illustrated Overview”, In Abu-Jaber, N., Bloxam, E.G., Degryse, P., and Heldal, T., (eds.) QuarryScapes: Ancient Stone Quarry Landscapes in the Eastern Mediterranean, Geological Survey of Norway, Special Publication 12 (2009), pp. 7-50.
  32. Hsu (Sh.), Infrared Spectroscopy, Handbook of Instrumental Techniques for Analytical Chemistry, USA, 2000.
  33. Hunnur (A.T.), Smectite to Illite Transformation: Relevance to Pore Pressure in the Subsurface, Masc., Thesis, Mewbourne School of Petroleum and Geological Engineering, University of Oklahoma, USA, 2006.
  34. Isfahani (Forood), Redaelli (Elena), Lollini (Federica), Li (Weiwen), Bertolini (Luca), “Effects of Nanosilica on Compressive Strength and Durability Properties of Concrete with Different Water to Binder Ratios”, Advances in Materials Science and Engineering (2016), pp. 1-16.
  35. JCPDS, Jaint Committee on Powder Diffraction Standards, Index to the Powder Diffraction File, American Society for Testing and Materials, Pennsylvania, 1967.
  36. Jensen (Keld), Bøgelund (Jesper), Jackson (Petra), Jacobsen (Nicklas), Birkedal (Renie), Clausen (Per), Saber (Anne), Wallin (Håkan), Vogel (Ulla), Carbon Nanotubes: Types, Products, Market, and Provi-Sional Assessment of the Associated Risks to Man and the Environment, The Danish Environmental Protection Agency, Denmark, 2015.
  37. Jester (Thomas), Twentieth-Century Building Materials History and Conservation, Getty Conservation Institute, Los Angles, 2014.
  38. Kaushik (B.K.), Majumder (M.K.), “Carbon Nanotube: Properties and Applications, in Carbon Nanotube Based VLSI Interconnects”, Applied Sciences and Technology, SpringerBriefs (2015), pp. 17-37.
  39. Khalafalla (Mohamed), Hodhod (Osama), Adam (Ihab), “Improving the Mechanical and Durability Properties of Cement Mortar by Nano Titanium”, Journal of Engineering Sciences 43 (5), 2015, pp. 663-681.
  40. Lucas (S.S.), Ferreira (V.M.), de Aguiar (Barroso), “Incorporation of Titanium Dioxide Nanoparticles in Mortars, Influence of Microstructure in the Hardened State Properties and Photocatalytic Activity”, Cement and Concrete Research 43 (2013), pp. 112-120.
  41. Maravelaki (N.), Lionakis (E.), Kapridaki (C.), Agioutantis (Z.), Verganelaki (A.), Perdikatsis (V.), “Characterization of Hydraulic Mortars Containing Nano-Titania for Restoration Applications”, 12th International Congress on the Deterioration and Conservation of Stone, Columbia University, New York, 2012.
  42. Metaxa (Z.S.), Pasiou (E.D.), Dakanali (I.), Stavrakas (I.), Triantis (D.), Kourkoulis (S.K.), “Carbon Nanotube Reinforced Mortar as A Sensor to Monitor the Structural Integrity of Restored Marble Epistyles Under Shear”, 21st European Conference on Fracture, ECF21, 20-24 June 2016, Catania, Italy, Procedia Structural Integrity 2 (2016), pp. 2833-2840.
  43. Milliken (K.L.), “Late Diagenesis and Mass Transfer in Sandstone-Shale Sequences”, Treatise on Geochemistry 7 (2003), pp. 159-190.
  44. Millrath (S.), Kozlova (S.), Shimanovich (M.C.), “New Approach to Beneficiation of Dredged Material as a Filler”, World Dredging (Mining & Construction) 37 (11),  2001, pp. 8-20.
  45. Mohammed (BS), Khed (VC), Nuruddin (MF), “A Review on Nano-Silica Based Concrete”, Journal of Nanomed Nanoscience (5), 2017, pp. 1-4.
  46. Musacchi (Jessica), Gonçalves (Teresa), “Influence of Nano-Lime and Nano-Silica Consolidants in the Drying Kinetics of Three Porous Building Materials”, Proceedings of the Laboratório Nacional de Engenharia Civil, Lisboa, Brazil, 2014.
  47. Otero (Jorge), Charola (Elena), Grissom (Carol), Starinieri (Vincenzo), “An Overview of Nanolime as a Consolidation Method for Calcareous Substrates”, Ge-conservación 11 (2017), pp. 71-78.
  48. Overton (James), Some Aspects of Induced Development in Egypt Under Muhammad Ali Pasha and Khedive Ismail, Master Thesis, Simon Faster University, 1971.
  49. Palomo (A.), Blanco-Varela (M.T.), Martinez-Ramirez (S.), Puertas (F.), Fortes, (C.), Historic Mortars: Characterization and Durability, New Tendencies for Research, Madrid, Spain, 2004.
  50. Pandey (Parijat), Dahiya (Mandeep), “Carbon nanotubes: Types, Methods of Preparation and Applications”, International Journal of Pharmaceutical Science and Research 1 (4), 2016, pp. 15-21.
  51. Pavía (Sara), Roundtree (Susan), “An Investigation into Irish Historical Ceramics: The Brick of Arch Hall, Wilkinstown, Co. Meath”, Proceedings of the Royal Irish Academy 105 (6), 2005, pp. 221–242.
  52. Rashad (Alaa), “A Synopsis about the Effect of Nano-Titanium Dioxide on Some Properties of Cementitious Materials – A short guide for civil engineer”, Rev. Adv. Mater. Sci. 40 (2015), pp. 72-88.
  53. Robert (C.M.F.), Speweik (J.P.), “Repointing Mortar Joints in Historic Masonry Buildings”, in Preservation Brief (2), National Park Service, HPS national park service, Washington DC, 1998.
  54. Saleh (Najat), Ibrahim (Raheek), Salman (Ali), “Characterization of Nano-Silica Prepared from Local Silica Sand and its Application in Cement Mortar Using Optimization Technique”, Advanced Powder Technology 26 (2015), pp.1123–1133.
  55. Toumbakari (E.E.), Lime-Pozzolan-Cement Grouts and Their Structural Effects on Composite Masonry Walls, Ph.D., Thesis, Katholieke Universiteit Leuven, Faculteit Toegepaste Wetenschappen, Departement Burgerlijke Bouwkunde, Laboratorium Reyntjens, Heverlee, Belgium, 2002.
  56. Vojtechovsky (Jan), Bayer (Karol), International workshop on Nano-Lime for Conservation of Stone, Plaster and Architectural Surfaces, Final Report, Pöide, Norway, 2016.
  57. Xeidakis (G.), Koudoumakis (P.), Tsirambides (A.), “Road Construction on Swelling Soils: the Case of Strymi Soils, Rhodope, Thrace, Northern Greece”, Bulletin of Engineering Geology and the Environment (63), Springer-Verlag, 2004, pp. 93-101.
  58. Yılmaz (I.), “Gypsum/anhydrite: Some Engineering Problems”, Bulletin of Engineering geology and the Environment (59), Springer-Verlag, 2001, pp. 227-230.
  59. Zainuddin (Atiqah), Mukri (Mazidah), Jamal (Norullain), Azmi (Azizah),  Lat (Diana), “Study of Nano Koalinite as Additives in Kaolinite Clay to Develop New Clay Liner Design”, Article Derived from the Project: Evaluation of Strength Characteristics for Palm Kernel Oil-Based Polyurethane (PKO-P) as a Ground Improvement Method, Malaysia, 2015, pp. 1-15.
Statistics
Article View: 409
PDF Download: 455