DRYING SOME MEDICINAL AND AROMATIC PLANTS BY MICROWAVE | ||
| Misr Journal of Agricultural Engineering | ||
| Article 10, Volume 35, Issue 3, July 2018, Pages 953-974 PDF (631.91 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/mjae.2018.95571 | ||
| Author | ||
| Taghreed H. Ahmed | ||
| Lecturer of Agric. Eng., Fac. of Agric., Zagazig Univ., Egypt | ||
| Abstract | ||
| In this investigation, four different medicinal and aromatic plants chamomile, mint, sage and basil were dried by microwave under three different levels of power density (6.7, 10 and 20) W.g-1 in order to study drying characteristics, energy consumption and drying efficiency for microwave drying. The experimented plants were dried to the final moisture content during (12,10 and 9) min for chamomile, while mint leaves took 9, 6 and 4 min, it took 9, 7 and 5 min for drying sage leaves and basil leaves took 14, 8 and 5 min for power density of (6.7, 10 and 20)W.g-1 respectively. The minimum specific energy consumption and maximum drying efficiency were 4.96 MJ.kg-1 H2O and 45.52% were computed for drying sage samples using 6.7 W.g-1 power density. Among the mathematical models investigated there are six thin layer drying models were fitted to the experimental moisture ratio data, the page and page I models satisfactorily described the drying behavior of basil leaves at 6.7 W.g-1 and mint leaves at 10, 20 W.g-1 with highest r2 values but for the other treatments Newton model and Henderson and Pabis model were the best. The moisture diffusivity increased with microwave power density. The lowest values of effective moisture diffusivity were (5.03739×10-8, 6.01782×10-10, 1.72664×10-9, 5.769×10-10 m2.s-1) of chamomile, mint, sage, basil respectively at the lowest power density. | ||
| References | ||
|
Agrawal, Y. C., & R. P. Singh, (1977). Thin layer drying studies on short grain rough rice. ASAE, Paper No: 3531.
Akpinar E. K., Y. Bicer and C. Yildiz (2003). Thin layer drying of red pepper. Journal of Food Engineering, 59, 99–104.
Akpinar, E. K., A. Midilli and Y. Bicer (2003a). Single layer drying behavior of potato slices in a convective cyclone dryer and mathematical modeling. Energy Conversion and Management, 44, 1689–1705.
Akpinar, E. K., A. Midilli and Y. Bicer (2003b). Experimental investigation of drying behaviour and conditions of pumpkin slices via a cyclone-type dryer. Journal of the Science of Food and Agriculture, 83, 1480–1489.
Amr S. and S. Dordevic ( 2000). The investigation of the quality of Sage (Salvia officinalis L.) originated from Jordan. Facta Universitatis, 1: 103–108.
AOAC. 2002. AOAC Official Method 925.10 - Solids (Total) and Moisture in Flour, Air Oven Method. In Official Methods of Analysis of AOAC International, 17th Ed., 2nd Rev., Ch 32, p 1. Gaithersburg, MD: The Association of Official Analytical Chemists, International.
Arslan, D., and M.M.Ozcan. 2010. Study the effect of sun, oven and microwave drying on quality of onion slices. LWT – Food Science and Technology, 43(7):1121-1127.
Chhninman, M. S. (1984). Evaluation of selected mathematical models for describing thin layer drying of in-shell pecans. Transactions of the ASAE, 27, 610–615.
Crank, J. (1975). The Mathematics of Diffusion, Clarendon Press, Oxford, U.K..
Diamante, L. M., & Munro, P. A. (1991). Mathematical modeling of hot air drying of sweet potato slices. International Journal of Food Science and Technology, 26, 99.
Demirhan E. and B. Özebk (2010). Microwave drying characteristics of basil. Journal of Food processing and preservation. Volume 34, Issue 3 Pages 476–494.
Doymaz, I. (2004). Convective air drying characteristics of thin layer carrots. Journal of Food Engineering, 61, 359–364.
Doymaz, I. (2005). Sun drying of figs: an experimental study. Journal of Food Engineering, 71, 403–407.
Darvishi, H. (2012). Energy consumption and mathematical modeling of microwave drying of potato slices. Agric Eng Int: CIGR Journal Vol. 14, No.1.
Erenturk S., M.S.Gulaboglu and S.Gultekin (2004). The thin layer drying
characteristics of rosehip. Biosys. Eng., 89(2): 159-166.
Ertekin, C., and O. Yaldiz (2004). Drying of eggplant and selection of a suitable thin layer drying model. Journal of Food Engineering, 63, 349–359.
Erle, U. (2000).Untersuchungen zur Mikrowellen-Vakuumtrocknung von Lebensmitteln, Ph.D.Thesis, Universität Karlsruhe, Aachen, Shaker Verlag.
Gallawa, J.C. and Microtech Productions. Copyright © 1989-2005.
Günhan, T., V.Demir, E.Hancioglu and A.Hepbasli (2005). Mathematical modelling of drying of bay leaves. Energy Conversion and Management, 46(11–12), 1667–1679.
Gölükcü, M. (2015). The Effects of drying methods, packaging atmosphere and storage time on dried pomegranate aril quality. J. of Agric. Sciences. 21: 207 – 2019.
Hayes, G.D. (1987). Food Engineering Data Handbook. England: Longman Scientific and Technical.
Hossain, M. A. and B. K. Bala (2002). Thin-layer drying characteristics for green chilli. Drying Technology, 20(2), 489–505.
Kouhila M., A. Belghit, M. Daguenet and B.C. Boutaleb (2001). Experimental determination of the sorption isotherms of mint (Mentha viridis), sage (Salvia officinalis) and verbena (Lippia citriodora). Journal of Food Engineering, 47: 281–287.
Liu, Q., & F. W. Bakker-Arkema, (1997). Stochastic modeling of grain drying, Part 2: Model development. Journal of Agricultural Engineering Research, 66, 275–280.
Madamba, P.S. (2003). Thin layer drying models for osmotically pre-dried young coconut. Dry. Technol. 21,1759–1780.
Maskan A, Kaya S, Maskan M (2002). Hot air and sun drying of grape leather (pestil). J. Food Eng., 54: 81-88.
Minaei, S., A. Motevali, E. Ahmadi, and M.H. Azizi, (2012). Mathematical models of drying pomegranate arils in vacuum and microwave dryers. J. Agr. Sci. Tech, 14, 311-325.
Midilli, A. and H. Kucuk (2003). Mathematical modelling of thin layer drying of pistachio by using solar energy. Energy Conversion and Management, 44, 1111–1122.
O’Callaghan, J. R., D. J. Menzies, & P. H. Bailey, (1971). Digital simulation of agricultural dryer performance. Journal of Agricultural Engineering Research, 16, 223–244.
Ozbek, B., and G. Dadali. 2007. Thin-layer drying characteristics and modeling of mint leaves undergoing microwave treatment. Journal of Food Engineering, 83(4): 541–549.
Soysal Y. (2004). Microwave drying characteristics of parsley. Biosystems Engineering: 89(2):167–173.
Soysal, A., S. Oztekin, and O. Eren. (2006). Microwave drying of parsley: modelling, kinetics, and energy aspects. Biosystems Engineering, 93(4): 403–413.
Simal S., A. Femenia, M. C. Garau and C. Rosella (2005). Use of exponential, Page_s and diffusional models to simulate the drying kinetics of kiwi fruit. Journal of Food Engineering, 66(3), 323–328.
Wang, Z., Sun, J., Chen, F., Liao, X. and Hu, X. (2007). Mathematical modeling on thin layer microwave drying of apple pomace with and without hot-air pre drying. J. Food Eng. 80(2), 536–544.
Westerman, P. W., G. M.White, & I. J. Ross, (1973). Relative humidity effect on the high temperature drying of shelled corn.
Zhang, Q., & J. B. Litchfield, (1991). An optimization of intermittent corn drying in a laboratory scale thin layer dryer. Drying Technology, 9, 383–395.
Zhang, M., J.tang, , A.S. Mujumdar and S.wang (2006). Trends in microwave-related drying of fruits and vegetables. Trends Food Sci. Tech. 17(10), 524–534. | ||
|
Statistics Article View: 224 PDF Download: 290 |
||
