DESIGN OF INDUSTRIAL BIOMETHANE DIGESTER ATTACHED WITH UPGRADING AND STORAGE UNITS | ||
| Misr Journal of Agricultural Engineering | ||
| Article 18, Volume 35, Issue 2, April 2018, Pages 695-710 PDF (376.92 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/mjae.2018.95819 | ||
| Author | ||
| M. M. Badr | ||
| Assistant professor of Agric. Eng., Fac. of Agric., Zagazig Univ. Egypt. | ||
| Abstract | ||
| The recent rise in energy demand to support industrialization and civilization is resulting in increased stress on conventional energy sources. Faced with the accompanying problem of climate change, research in renewable energies, especially their commercialization, has never been more important. Biogas production is a major renewable energy source. The rabbit wastes could not be completely used in biogas production as a result of certain restrictions are related with it, prevalent among these are the increase hydraulic retention time, low both gas production and calorific value this could be essentially attributed to the lower biodegradability of this wastes. So, efforts are required to take off its constraint in order to spread this technology and fully commercialized. This research focused on the design and construction of an integrated geometrical system to produce, purify, and store methane that can be implemented in commercial-size models in general and for rabbit farms especially. The results showed that the highest methane production recorded was 241.73 l/kgOTS for a three-time agitation rate of rabbit droppings. The methane concentration in the raw biogas was 57.5, 62.5 and 67.5%. The calorific values of purified biogas reached a high of 33.35 kJ/l. The methane content increased by 37.39% after undergoing the upgrading process at a constant gas pressure of 8.53 mbar and a methane proportion in the raw biogas of about 67.5%. | ||
| References | ||
|
A.O. A. C. 2000. Official Methods of Analysis. Association of Official Analytical Chemist. EUA.
Bajracharya, R., A. Dhungana, N. Thapaliya and G. Hamal 2009. Purification and compression of biogas. A research experience. J Institute Eng., 7,1-9.
Bjornsson, L., B. Mattiasson and T. Henrysson 1997. Effects of support material on the pattern of volatile fatty acid accumulation at overload in anaerobic digestion of semi-solid waste. ApplMicrobiol Bio technol, 47, 640–644.
Brehmer, M., T. Eppinger and M., Kraume 2012. Influence of rheology on the flow pattern in stirred biogas plants. Chem. Ing. Tech., 84, 2048–2056.
Brunetti, A., Y. Sun, A. Caravella, E. Drioli and G. Barbieri 2015. Process Intensification for greenhouse gas separation from biogas: More efficient process schemes based on membrane-integrated systems. International Journal of Greenhouse Gas Control, 35, 18–29.
El-Bakhshwan, M. K., S. M. A. Abd El-Ghafar, M. F. Zayed and A. E. Shazly 2015. Effect of mechanical stirring on biogas production efficiency in large scale digesters. J. Soil Sci. and Agric. Eng., Mansoura Univ., 6, 47 – 63.
Gaikwad, V. R. and P. K. Katti 2015. Biogas Compression and Bottling: A Solution to Energy Crises. International Journal of Computer Applications (0975 – 8887).
Karim, K., R. Hoffmann, K. T. Klasson and M. H. Al-Dahhan 2005. Anaerobic digestion of animal waste: Effect of mode of mixing. Water research, 39(15), 3597-3606.
Klaus, V. M. 1988. Engines for biogas. A Publication of the Deutsches Zentrum für Entwicklungstechnologien GATE , a Division of the Deutsche Gesellschaft für Technische Zusammenarbeit (GTZ) GmbH , Germany.
Kowalczyk, A., E. Harnisch, S. Schwede, M. Gerber and R. Span 2013. Different mixing modes for biogas plants using energy crops. Appl. Energy, 112,465–472.
Lemmer, A., N. Hans-Joachim and J. Sondermann 2013. How Efficient are Agitators in Biogas Digesters? Determination of the Efficiency of Submersible Motor Mixers and Incline Agitators by Measuring Nutrient Distribution in Full-Scale Agricultural Biogas Digesters Energies, 6, 6255-6273.
Lesteur, M., V. Bellon-Maurel, C. Gonzalez, E. Latrille, J. M. Roger, G. Junqua, and J. P. Steyer 2010. Alternative methods for determining anaerobic biodegradability: a review. Process Biochemistry, 45(4), 431-440.
Nallamothu, R. B., A. Teferra, and B. A. Rao (2013). Biogas purification, compression and bottling. Global journal of engineering, design and technology, 2(6), 34-38.
Okeke, C. E. and V. A. Ezekoye 2006. Design, construction and performance evaluation of plastic biodigester. The Pacific Jo. Sc. Tec.7, Nsukka, Nigeria.
Ray, N., M. Mohanty and R. Mohanty 2016. Biogas Compression and Storage System for Cooking Applications in Rural Households. International journal of renewable energy research. 6, 593-598. | ||
|
Statistics Article View: 152 PDF Download: 334 |
||
