DRYING CHARACTERISTICS AND QUALITY CHANGES OF MORINGA LEAVES | ||
| Misr Journal of Agricultural Engineering | ||
| Article 11, Volume 33, Issue 3, July 2016, Pages 947-960 PDF (695.16 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/mjae.2016.97760 | ||
| Authors | ||
| A. E. Suliman1; Y. B. Abdelhay2; A. E. Saad3 | ||
| 1Prof., Agric. Eng. Dept., Fac. Of Agric., Giza, Egypt. | ||
| 2Assistant Prof., Agric. Eng. Dept., Fac. Of Agric., Cairo Univ., Giza, Egypt. | ||
| 3Graduate Student of Agric. Eng. Dept., Fac. Of Agric., Cairo Univ., Giza, Egypt. | ||
| Abstract | ||
| The drying characteristics and quality changes of moringa oleifera leaves as a medicinal and aromatic plants were studied and investigated by using a laboratory dryer with initial moisture content of 86.7 % (wet base). Three different drying air temperatures (40, 50 and 60 ºC) with three different drying air velocities (0.45, 1.0 and 1.5 m/s) were functioned during this laboratory experiment. The quality of dried moringa leaves including protein, ascorbic acid (vitamin C), calcium and potassium were estimated. The experiment was carried out at Agricultural Engineering Department, Cairo University, Egypt in 2015.The obtained results demonstrated that the increase of drying temperature and air velocity resulted in lower moisture content and the drying rate was faster at the beginning than at the end for all treatments. At drying air temperature 60°C with air velocity 1.5 m/s showed the best data, at which in dried moringa, the moisture content decreased to 9.35% within drying time 5.5 hours, the average drying rate was 14.06 %/h, drying ratio was 4.42:1 and the average evaporating rate was 28.13 gmwater/h. Also, the quality tests of dried moringa leaves showed that, the best quality in terms of higher retention of protein and potassium at air temperature 60°C with air velocity 1.5 m/s, while at air temperature 40°C with air velocity 0.45 m/s showed the best quality in terms of higher retention of vitamin C and calcium. | ||
| Keywords | ||
| Drying characteristics; Moringa leaves; Quality | ||
| References | ||
|
Abdel-Galil, H.S. and A.A. El-Nakib. (2008). Effect of natural convection solar drying on quality of peppermint. The 15th Annual Conference of the Misr Society of Ag. Eng.
Ali, M. A., Yusof, Y. A., Chin, N. L., Ibrahim, S. M. A. and Basra (2014). Drying kinetics and colour analysis of moringa oleifera leaves. 2nd International Conference on Agricultural and Food Engineering, Agriculture and Agricultural Science Procedia 2: 394 – 400.
Amer, B.M.A. (2012). Determination of optimum conditions for thin-layer drying of lemon balm leaves (Melissa Officinalis L.). Misr J. Of Ag. Eng., 29 (1): 359-376.
AOAC, (1970). Official methods of analysis. Association of Official Analytical Chemists, Washington D.C. 11ed.
AOAC, Association of Official Analytical Chemists (1990). Official Methods of Analysis. 15th ed. Association of Official Analytical Chemists, Washington D.C., U.S.A.
AOAC, (1995). Official methods of analysis (16th Ed.). Arlington VA, USA: Association of Official Analytical Chemists.
Arafa, G. K. (2007). Optimum drying conditions for thin-layer drying of sweet basil. Misr J. Ag. Eng., 24(3):540-556.
Djeridane, A., Yousfi, M., Nadjemi, B., Boutassouna, D., Stocker, P. and Vidal, N. (2006). Antioxidant activity of some Algerian medicinal plants extracts containing phenolic compounds. Food chem. 97 (4): 654-660.
Fadhel, A., Kooli, S., Farhat, A. and Belghith, A. (2014). Experimental study of the drying of hot red pepper in the open air, under green house and in a solar drier. International Journal of Renewable Energy & Biofuels.
Hashim, N., Daniel, O. and Rahamana, E. (2014). A preliminary study: kinetic model of drying process of pumpkins (Cucurbita Moschata) in a convective hot air dryer. Agriculture and Agricultural Science Procedia, 2: 345 – 352.
Hassan, M.M.A. (2015). Solar drying performance study of some crops (mint, okra and grapes) I- assessing the drying rates. Misr J. Of Ag. Eng., 32(1):205-222.
Hossain, M. A., Al-Toubi, W. A. S., Weli, A. M., Al-Riyami, Q. A. and Al-Sabahi, J. N. (2013). Identification and characterization of chemical compounds indifferent crude extracts from leaves of omani neem. Journal of Taibah University for Science 7: 181–188.
Kassem, A. M., I. E. El-Batawi and Mahassen M. S. (2006). Effect of solar energy and other drying methods on quality of some medicinal plants. The 14th Annual Conference of the Misr Society of Ag. Eng., 22 November :766:782.
Mujumdar, A.S. (1995) "Handbook of industrial drying" 2 nd. Ed. revised and expanded. 2:150-174.
M.F.A. (1982). Methods of food analysis. NiponShokuhin Kogyo Gakaishi, Tokyo.
Ozguven, M. and Tansi, S. (1999). Determination of yield and quality in marjoram as influenced by development periods. Turkish-J of Agr. and Forestry. 23(1): 11-17.
Ȍztekin, S. and Martinov, M. (2007). Medicinal and aromatic crops harvesting, drying and Processing. Haworth Food and Agricultural Products Presstm, An Imprint of the Haworth Press, Inc., 10 Alice Street, Binghamton, New York 13904-1580 USA.
Premi, M.; Sharma, H.K.; Sarkar, B.C. and Singh, C. (2010). Kinetics of drumstick leaves (Moringa oleifera) during convective drying. African Journal of Plant Science, 4 (10): 391-400.
Shokr, A. Z., E. A., Abdel Ghaffar, M. A., Rashwan and S. S., Shaaban (2011). Development of the drying characteristic coefficients of dried marigold plants by using of an electrical laboratory drying system. Misr J. Of Ag. Eng., 28 (1): 181-200.
Vinoth, B., Manivasagaperumal, R. and Rajaravindran, M. (2012). Phytochemical analysis and antibacterial activity of azadirachta indica ajuss. International Journal of Research in Plant Science, 2(3): 50-55. | ||
|
Statistics Article View: 302 PDF Download: 332 |
||
