DEHYDRATION OF ONION SLICES USING IR-REFRACTANCE WINDOW DRYING SYSTEM | ||
| Misr Journal of Agricultural Engineering | ||
| Article 23, Volume 29, Issue 1, January 2012, Pages 409-428 PDF (651.33 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/mjae.2012.102621 | ||
| Authors | ||
| Samir A. Tayel1; H. S. Alkatary1; K.S. Nagy2; O.S. Younes3 | ||
| 1Prof. Emt.,Ag.Eng.Dept., Faculty of Agriculture, Al- Azher University, Egypt. | ||
| 2Senior Researcher and Head of Food Eng. and Pack. Res. Dept., Food Tech. Res. Inst., Agric. Res. Center, Egypt. | ||
| 3Assistant Researcher , Food Eng. and Pack. Res. Dept., Food Tech. Res. Inst., Agric. Res. Center, Egypt. | ||
| Abstract | ||
| The aim of this research work was to study the drying behavior of onion slices using infrared radiation refractance window drying system, which the infrared radiation passed throw plastic membrane surface , where the water in the moist product creates a window, that allows for the passage of infrared energy and heat behaves as it and directly transferred to water present in the product, the water in the product on the plastic membrane surface evaporates, and the window of infrared energy closes and refracts back into the heated source, no longer exposing the product to heat and good quality product. The experiments of this work carried out at food engineering and packaging research dept. , Food Techn. Res. Institute, Agric. Research center. The drying behavior of onion slices using suggested dryer was examined and simulated for three different thin layer drying models ( Page , modified Page and Hendreson and Padis ) . Four levels of radiation intensity ( 1100 , 1750 , 2400 , 3050 W / m2) and for levels of drying air velocity ( 0.1 , 0.5 , 1 and 1.5 m / s ) were studied at 45 ºC temperature and 20 % relative humidity . The results showed that : The recorded drying time for drying whole onion slices from an initial moisture content of about 612 - 614.28 % d.b. to a final moisture content of about 13.75 – 15 % d.b. were 50 – 140 minutes under different drying parameters . - The following equation can described the relation ship between drying time ( T ) , radiation intensity ( I ) and air velocity ( V ) with the best fit : T = 80 + 100V - 1600 I, (R² = 0.9911) - The thermal efficiency of the IR-refractance window drying system was varied between 54.47% to 46.43% , specific energy consumption varied between 4.39 KJkgˉ¹to5.15 KJkgˉ¹under different drying parameters. - The total capacity of the dryer is a bout 0.326 Kg/h the calculated operation cost of the dryer approaches about 8.89 LE/kg of dried whole onion slices . | ||
| References | ||
|
A.O.A.C. (1995). Official method of analysis, association of official analytical chemists. Washington, D.C. USA.
Afzal, T. M., Abe, T., & Hikida, Y. (1999). Energy and quality aspects during combined FIR-convective drying of barley. Journal of Food Engineering, 42, 177–182.
Awady, M. N., Mohamed, S.A., El Sayed, A. S., and Hassanain, A. A., (1993). Utilization of solar energy.Boudhrioua,N.; P.Giampaoli and C.Bonazzi (2003): “Changes in aromatic components of banana during ripening and air drying”. Lebensmittel Wissenschaft und Technology, 36: 633-642.
Brendan, I.A., T Juming and G.E Charles (1999). Evaluation of the energy efficiency and quality retention for refractance window system. Dept. Of Biological systems Eng. Washington stat. Univ. Project report 1-36.
Dilip,J. and B.P.Pankaj (2004): “Selection and evaluation of thin layer drying models for infrared radiative and convective drying of onion slices”. Biosystems Engineering, 89 (3): 289-290.
Feng, H,J. Tang and R.P. Cavalierie (1999) . combined microwave and sprouted bed drying of diced apples : Effect of drying condition on kinetics and product temperature, Drying technology. 17 ( 10 ) 1981 – 1998.
Henderson, S. M, and S. Pabis (1961). Grain drying theory. II. Temperature effects on drying coefficients. Journal of Agricultural Engineering Research, 6, 169–174.
Hebbar,H.U.;K.H.Vishwanathan and M.N.Ramesh (2004): “Development of combined infrared and hot air dryer for vegetables”. Journal of Engineering, 65: 557-563.
Jindal, V.K. and V. G. Reyes, ( 1987 ). Conduction heating of rough rice accelerated drying. Paper no. 87-6043, American society of Agricultural Engineers (ASAE) Summer Metting Baltimore June 28 July 1, ASAE, sr. Joseph. Mi.
Page,G.E. (1949): “Factors influencing the maximum rates of air drying shelled corn in thin layers”.M.S.Thesis, Department of Mechanical Engineering, Purdue University, Purdue, USA.
Sacilik,K. and G.Unal (2005):“Dehydration characteristics of Kastamonu garlic slices”. Biosystems Engineering, 92 (2): 207-215.
Sharma,G.P.; R.C.Verma and P.B.Pathare (2005): “Mathematical modeling of infrared radiation thin layer drying of onion slices”. Journal of Food Engineering, 71: 282-286.
Kathira van Krishnamurthy, Harpreet Kaur Khurana, Soojin Jun, Joseph Irudayaraj, and Ali Demirci (2008). Infrared Heating in Food Processing: An Overview. Comprehensive reviews in food science and food safety _ Vol 7, 2008 | ||
|
Statistics Article View: 187 PDF Download: 337 |
||
