EFFECT OF COLD STORAGE USING SOLAR ENERGY ON QUAILTY OF POMEGRANATE FRUITS | ||
| Misr Journal of Agricultural Engineering | ||
| Article 11, Volume 33, Issue 2, April 2016, Pages 491-506 PDF (471.85 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/mjae.2016.97978 | ||
| Authors | ||
| Ahmed E. Suliman1; Yousry. B. Abd Elhay2; M. A Kassem3; Heba G. R. Youns4 | ||
| 1Professor of Agricultural Engineering, Fac. Agric., Cairo University, Egypt. | ||
| 2Assistant Professor of Agricultural Engineering, Fac. Agric., Cairo University, Egypt. | ||
| 3Assoc. Prof., Mechanical Power, Dept., Fac. Engineering, Cairo University, Egypt. | ||
| 4Demonstrator, Agric. Eng., Fac. Agric. Cairo University, Egypt. | ||
| Abstract | ||
| This study aims to evaluate a cold storage system using solar energy of pomegranate fruits (cv. Wonderful) for storage period 50 days under storing temperatures of (5 oC) and relative humidity of 90 -95 %. The storage process was done using two refrigeration systems one of them is a refrigerator driven by solar energy, the other one driven using electrical energy. The component of refrigerator driven by solar energy consists, two parallel photovoltaic cells (PV), two batteries, an inverter, and cables, In addition to refrigerator unit. Testing the PV system showed that, nine hours discharge time for one battery is available during connected to the cold storage. So it is necessary to use two batteries connected in series to be suitable for refrigerator driven power and Egyptian conditions, and can therefore run the cooling system throughout the day without interruption. The percentage of weight loss, hardness, and total soluble solid (TSS) for pomegranate fruits using refrigerator driven using photovoltaic cell were 8.46 %, 11.18 kgf, and 15.80% respectively; Meanwhile cold storage driven by electrical energy, these parameters were 8.79 %, 10.41 kgf, and 15.71% respectively. Operating cost using solar energy achieved the lowest cost compare with using electrical energy, therefore, can rely on the use of solar energy instead of electrical energy to operate the refrigeration unit. From the above results, pomegranate fruit inside PV driven refrigerator has a good quality compared with pomegranate fruit inside electrically driven refrigerator. | ||
| Keywords | ||
| pomegranate; quality; cold storage; solar energy | ||
| References | ||
|
A.O.A.C. (1995). Official Method of Analysis of Association of Official Agricultural Chemists. 15 th ed.
El Awady, M.N.; Abd El-Salam, M.F., Farrag, A.E. and Aboelghait, K.M. (2015). Low quality water treatment and deselimation abased on solar energy technologies. Misr J.Ag. Eng., 32 (2): 909-926 p.
Al-Said, F.A.; Opara, L.U. and Al-Yahyai, R.A. (2009). Physico-chemical and textural quality attributes of pomegranate cultivars (Punica granatum L.) grown in the Sultanate of Oman. J. Food Eng. (90):129-134 p.
Arendse, E.; Fawole, O.A. and Opara, U. L. (2014). Influence of storage temperature and duration on postharvest physico-chemical and mechanical properties of pomegranate fruit and arils, Journal of Food, 1-10 p.
Basediya, A.L.; Samuel, D. v. k. and Beera, V. (2013). Evaporative cooling system for storage of fruits and vegetables - a review. J. Food Sci Technol 50(3):429–442 p.
Caleb, O. J.; Mahajan, P. V.; Manley, M. and Opara, U. L. (2013). Evaluation of parameters affecting modified atmosphere packaging engineering design for pomegranate arils. International Journal of Food Science and Technology, (48): 2315- 2323 p.
Darwesh, M. A.; Elmetwalli. H.; Derbala, A.; Fouda, T. and Morad, M. (2010). Manufacture and performance evaluation of solar absorption refrigeration unit for potato storage. Annual conference of the Misr society of Agric. Eng. (28):1907-1921 p.
Ekrami-Rad, N.; Khazaei, J. and Khoshtaghaza, M. H. (2011). Selected Mechanical properties of pomegranate peel and fruit. International Journal of Food Properties, (14 :( 570–582 p.
Elyatem, S. M. and Kader, A. A. (1984). Post-harvest physiology and storage behaviour of pomegranate fruits. Scientia Horticulturae, (24): 287–298 p.
Fawole, O.A.; Opara, U.L. and Theron, K.I., (2012). Chemical and phytochemical properties and antioxidant activities of three pomegranate cultivars grown in South Africa. Food Bioprocess Technol. (5): 2934–2940 p.
Fawole, O. A. and Opara, U. L. (2013). Changes in physical properties, chemical and elemental composition and antioxidant capacity of pomegranate (cv. Ruby) fruit at five maturity stages. Scientia Horticulturae, (150):37- 46 p.
Hamed, A.H.E. (2013). Prospects of using solar double – effect absorption air conditioning in Egypt. Master of Science in mechanical power engineering. Faculty of Engineering at Cairo University, 142 p.
Holt, C. B. (1970). Measurement of tomato firmness with a universal testing machine. Journal of Texture Studies, (1): 491–501 p.
Horticultural Res. Inst. (2014). Data on pomegranate statistics, Citrus Div., Hort.Res. Inst., A.R.C.
Hussein, Z.; Caleb, O.J.; Jacobs, K.; Manley, M. and Opara, U. L. (2015). Effect of perforation-mediated modified atmosphere packaging and storage duration on physicochemical properties and microbial quality of fresh minimally processed ‘Acco’ pomegranate arils, LWT - Food Science and Technology 64: 911- 918 p.
Khalil, A. Mubarak, A. Kaseb, S. (2010). Road map for renewable energy research and development In Egypt. University of Cairo, Journal of Advanced Research (1): 29–38 p.
Mphahlele, R. R.; Fawole, O.A. and Stander, M.A. (2014). Preharvest and postharvest factors influencing bioactive compounds in pomegranate (Punica granatum L.)-A review. Scientia Horticulturae 178: 114–123 p.
Miguel, M.G.; Neves, M.A. and Antunes, M.D., (2010). Pomegranate (Punica granatum L.): a medicinal plant with myriad biological properties. A short review. J. Med. Plants Res. (4):2836–2847 p.
Ngcobo. M. E.K.; Delele. M. A.; Opara. U.L. and Meyer C. J. b. (2013). Performance of multi-packaging for table grapes based on airflow, cooling rates and fruit quality. Journal of Food Engineering (116): 613–621 p.
Opara, L.U.; Al-Ani, M.R. and Al-Shuaibi, Y. (2009). Physico-chemical properties, vitamin C content, and antimicrobial properties of pomegranate fruit (Punica granatum L.). Food Bioprocess Tech. (2): 315–321p.
Qenawy. A. M.; El-Dib. A. F. and Ghoraba .M. M.; (2004). Evaluation and Performance Study of Solar-Powred Einstein Refrigeration Cycle. Canadian Solar Buildings Conference Montreal, August 20-24 p. | ||
|
Statistics Article View: 151 PDF Download: 271 |
||
