EFFECT OF DIFFERENT DRYING METHODS ON THE PHYSICAL PROPERTIES AND QUALITY OF SOME FRUIT PEELS | ||
| Misr Journal of Agricultural Engineering | ||
| Article 12, Volume 33, Issue 2, April 2016, Pages 507-526 PDF (796.44 K) | ||
| Document Type: Original Article | ||
| DOI: 10.21608/mjae.2016.97979 | ||
| Authors | ||
| Mona M. A. Hassan1; K. I. Wasfy2 | ||
| 1Associate prof. of Agric. Eng., Fac. of Agric., Zagazig Univ., Egypt. | ||
| 2Lecturer of Agric. Eng., Fac. of Agric., Zagazig Univ., Egypt. | ||
| Abstract | ||
| Fruit peel represents approximately 30-40 g/100g of the fresh fruit mass and could be used to develop value-added products rather than causing pollution of the environment. Fruit peels of orange, lemon, pomegranate and grapefruit were dried using two different drying methods (oven and microwave) under different fruit peels masses of 50, 100, 150 and 200g in order to study the drying behavior in terms of specific energy, drying efficiency and product quality. Mathematical models of the oven and microwave dryers were investigated based on the experimental data in order to predict their performance. The obtained data revealed that the use of a microwave was accompanied with higher drying rates of fruit peels, higher drying efficiency and lower specific energy compared with electric oven. The best product quality was achieved in the case of using fruit peels of 50g in the microwave and 200g in the oven comparing with other peels masses. In oven, Newton and Henderson and Pabis models showed good agreement with orange and lemon, while Page and Modified Page (I) were the best descriptive models for pomegranate peels. Regard to the drying in microwave, Page and Modified Page (I) models showed good agreement with all fruit peels (orange, lemon, pomegranate and grapefruit). | ||
| References | ||
|
Agrawal, Y. C. and R. P. Singh (1977). Thin layer drying studies on short grain rough rice. ASAE. Paper No: 3531.
Andrea, V; N. Nadia, R. M. Teresa and A. Andrea (2003). Analysis of some Italian lemon liquors (Limoncello). J. of Agric. Food Chemistry. 51(17): 4978 – 4983.
AOAC (Association of Official Analytical Chemists) (2000). Official methods of analysis, 17 Ed. Washington D.C.
Bampidis V. A. and P. H. Robinson (2006). Citrus byproducts as ruminant feeds: a review. Anim. Feed Sci. Technol. 128 (3/4): 175-217.
Bauer, J. L; B. Harbaum-Piayda and K. Schwarz (2012). Phenolic compounds from hydrolyzed and extracted fiber rich by products. Food Science and Technology, 47 (2): 246 – 254.
Bejar, A. K; N. Kechaou and N. B. Mihoubi (2011). Effect of microwave treatment on physical and functional properties of orange (Citrus Sinensis) peel and leaves. J. Food Process and Technology. 2(2): 1 – 7.
Calín-Sánchez, Á; A. Figiel, F. Hernández, P. Melgarejo, K. Lech and Á. Carbonell-Barrachina (2012). Chemical composition, antioxidant capacity and sensory quality of pomegranate (Punica granatum) arils and rind as affected by drying method. Food and Bioprocess Technology. 6(7): 1 – 11.
Chhninman, M. S. (1984). Evaluation of selected mathematical models for describing thin layer drying of in-shell pecans. Transactions of the ASAE. 27: 610 – 615.
Diaz, G. R; J. Martı´nez-Monzo, P. Fito and A. Chiralt. (2003). Modeling of dehydration–rehydration of orange slices in combined microwave/air drying. Innovative Food Science and Emerging Technologies. 4(2): 203–209.
El-Adawy, T. A; E. H. Rehman, A. A. El-Bedawy and A. M. Gafar (1999). Properties of some Citrus seeds. Part 3. Evaluation as a new
source of potential oil. Nahrung. 43: 385 – 391.
Gölükcü, M. (2015). The Effects of drying methods, packaging atmosphere and storage time on dried pomegranate aril quality.J. of Agric. Sciences. 21: 207 – 2019.
Hayes, G. D. (1987). Food Engineering Data Handbook. England: Longman Scientific and Technical.
Lee, H. S. (1993). HPLC method for separation and determination of non-volatile organic acids in orange juice. J. Agric. Food Chem. 41.
Li, Y; C. Guo, J. Yang, J. Wei, J. Xu and S. Cheng (2006). Evaluation of antioxidant properties of pomegranate peel extract in comparison with pomegranate pulp extract. Food Chem. 96(2): 254-260.
Liu, Q. and F. W. Bakker-Arkema (1997). Stochastic modeling of grain drying, Part 2: Model development. J. of Agric. Eng. Res; 66, 275 – 280.
Mandalari G; R. N. Bennett, G. Bisignano, A. Saija, G. Dugo, R. B. Lo Curto, C. B. Faulds and K. W. Waldron (2006). Characterization of flavonoids and pectin from bergamot (Citrus bergamia Risso) peel, a major by-product of essential oil extraction. J. Agric. and Food Chem. 54:197 – 203.
Martínez, R; P. Torres, M. A. Meneses, J. G. Figueroa, J. A. Pérez-Álvarez and M. Viuda-Martos (2012). Chemical, technological and in Vitro antioxidant properties of mango, guava, pineapple and passion fruit dietary fiber concentrate.Food Chemistry, 135 (3): 1520 – 1526. http://dx.doi.org/10.1016/j.foodchem.2012.05.057
Meléndez, J; E. Bejines, M. vicario and J. Heredia (2004). Influence of the wavelength of detection. Ital. J. Food Sci. 16: 79 – 85.
Ming, L. C; R. O. Figueiredo, S. R. Machado and R. M. C. Andrade (1996). Yield of essential oil of and citral content in different parts of lemongrass leaves (Cymbopogon citratus (D.C.) Stapf.) Poaceae.Acta Horticulturae, Leuven, n.426, p.555–559.
Mousa, N. and M. Farid. (2002). Microwave vacuum drying of banana slices. Drying Technology. 20(10): 2055 – 2066.
O’Callaghan, J. R; D. J. Menzies and P. H. Bailey (1971). Digital simulation of agricultural dryer performance. J. of Agric. Eng. Res; 16: 223 – 224.
Rayaguru, K. and W. Routray (2011). Microwave drying kinetics and quality characteristics of aromatic Pandanus amaryllifolius leaves. International Food Res. J; 18(3):1035 – 1042.
Sharma, G. P; S. Prasad and A. K. Datta (2003). Drying kinetics of garlic cloves under convective drying conditions. J. of Food Science and Technology. 40 (1): 45 – 51.
Singh, R. P; K. N. C. Murthy and G. K. Jayaprakasha (2002). Studies on the antioxidant activity of pomegranate peel and seed extracts using in vitro models. J. Agric. Food. Chem; 50(1): 81-86.
Singleton, V. L. and J. A. Rossi (1965). Flavor effects and adsorptive properties of purified fractions of grape seed phenols. American J. of Enology Viticulture; 16: 144 – 158.
Skrubis, B. G. (1982). The drying of laurel leaves.Perfumer & Flavorist, New York. 7(5): 37 – 40.
Sorour, M. A; A. E. Rizk and D. M. Elsheikh (2014). Drying of pomegranate wastes. International J. of Advanced Technology in Eng. and Science. 2(10): 265 – 274. www.ijates.com
Soysal, A. (2004). Microwave drying characteristics of parsley. Bio-systems Eng; 89(2): 167–173.
Soysal, A; S. Oztekin and O. Eren (2006). Microwave drying of parsley: modelling, kinetics, and energy aspects. Bio-systems Eng; 93(4): 403 – 413.
Talens, C; M. C. Giráldez, C. Bald and P. J. Fito (2013). Thermodynamic model of microwave drying of citrus peel with different treatments. InsideFood Symposium, Leuven, Belgium.1–6.
Tippayawong, N; C. Tantakitti and S. Thavornun (2008). Energy efficiency improvements in longan drying practice. Energy, 33(7): 1137–1143.
Wang, C. Y. and R. P. Singh (1978). A single layer drying equation for rough rice. ASAE. Paper No: 3001.
Westerman, P. W; G. M. White and I. J. Ross (1973). Relative humidity effect on the high temperature drying of shelled corn. Transactions of the ASAE. 16: 1136 – 1139.
Yongsawatdigul, J. and S. Gunasekaran (1996). Microwave vacuum drying of cranberries, Part II: Quality evaluation. J. of Food
Process Eng; 20(12): 145 – 156.
Zhang, Q. and J. B. Litchfield (1991). An optimization of intermittent corn drying in a laboratory scale thin layer dryer. Drying Technology. 9: 383 – 395. | ||
|
Statistics Article View: 205 PDF Download: 218 |
||
